Need helps with codes P0420 and P0430 - DodgeTalk : Dodge Car Forums, Dodge Truck Forums and Ram Forums
DodgeTalk : Dodge Car Forums, Dodge Truck Forums and Ram Forums
 HOME  FORUMS  GALLERY  GARAGE  TECH  CLASSIFIEDS  LINKS  MEMBER MAP  ARCHIVE  SPONSORS
INFO SITE HELP DODGETALK MERCHANDISE ARCADE TELL-A-FRIEND STAFF CONTACT US AUTO LOANS


DodgeTalk.com is the premier Dodge forum on the internet. Registered Users do not see the above ads.Please Register - It's Free!
Go Back   DodgeTalk : Dodge Car Forums, Dodge Truck Forums and Ram Forums > Dodge Truck, SUV and Van Forums > Dodge Ram Truck 3rd Gen (02 08) Forums > 3G Dodge RAM - General Talk

Closed Thread
 
Thread Tools

weedahoe
 
  Need helps with codes P0420 and P0430 - Posted: 06-22-2010, 07:53 AM
weedahoe's Avatar
Tricked out Ram
Joined: Jul 2007
Posts: 12,520
City: Albany
State: GA
Status: Offline
Post #1

P0420 - Catalyst System Efficiency Below Threshold (Bank 1)

P0430 - Catalyst System Efficiency Below Threshold (Bank 2)

The catalytic converter has an oxygen sensor in front and behind it. When the vehicle is warm and running in closed loop mode, the upstream oxygen sensor waveform reading should fluctuate. The downstream O2 sensor reading should be fairly steady. Typically the P0420 code triggers the Check Engine Light if the readings of the two sensors are similar. This is indicative of (among other things) a converter that is not working as efficiently as it should be (according to specs). It is part of the vehicle emissions system.

-----------------------------------------------------------

So I guess both rear O2's are bad but its weird both go off at the same time. I have cleared the codes and even reset the PCM but they come back.

I have no cats and the CEL for the rear O2's is disabled through custom tuning.

http://dodgeram.info/tsb/2007/18-016-07.htm

Any ideas?
__________________
2004 2wd Dodge Ram QC w/a 5.7 with Royal Purple 5w-20 in the motor, RP Max ATF in the trans, 80-90w in the 4.56 Auburn LSD rolling on American Racing Dale Earnhart "Tank" 24s wrapped in Pirelli 325/45/24s (36" tires)

| Debadged | SRT-10 hood | Custom CAI | Fumoto oil valve | 12" of lift | Power Wire | 9007 Bi-Xenon 6k | 9006 Single Beam 6K | 2nd battery tray (2K CCA total) | Big 3 upgrade w/1ga wire | Altezza clear tails w/LEDs | Clear LED 3rd light | 26gal to 35gal fuel tank swap | Viair 380c air compressor | train horns | Ceramic pads (F&R) | Westin Nerfs | Chrome door/tailgate handles | Custom switch panel | Custom center console | B&M QuickSilver floor shifer | Xbox 360 | Audiobahn A8000V (1600w sub amp) | Audiobahn 2002V (400w mid/high amp) | 2 12" Kicker DVC CVRs in a FoxBox | 4 Kicker DS650s (front & rears) | 2 Kicker KS350s (dash) | 2 8" LCD screens in the sunvisors | 2 6" LCD screens in the headrest | Clifford 50.7x alarm | 20/15% tint | Diablo Trinity - custom and 93 tuned | Mopar 6.1 ignition conversion | Start ignition push button | KRC 210 cam | 6.1 springs & pushrods | 6.1 half covers | 180* T-stat | Taurus E-fan | Pacesetter ceramic LTs | dual DMH cutouts | (2) 4x14" round magnaflows | 4x24" tips | X pipe | Jimmy Jammers | Ported (85mm) TB | Innovate LC-1 wideband | Sonnax transmission pressure booster | Mopar slush mats | RBP grill | powder coated calipers | custom rim/grill lights |

Link to my gallery



Next projects:

- Custom center console
- B&M Quicksilver Floor shifter
- Custom CAI
View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote
Sponsored Links
Advertisement
 

KB112
 
 Posted: 06-22-2010, 11:04 PM
KB112's Avatar
Senior Member
Joined: Aug 2003
Posts: 22,992
City: Brentwood Nor Cal
State: CA
Status: Offline
View This User's Gallery View This User's Garage
View This User's Timeslip View This User's Dyno Entries
Post #2

Try putting in new front sensors and see what happens? Or just buy one and add it in, see if it goes away.
__________________
2004 5.7L Quad Cab
1/8: 9.113@70.814 --- 1/4: 14.365@95.470
Exterior: Blacked Out 06-20"s, 295/50-20 Falkens, 2/4 Drop - Hotchkis coils/DJM Flip, Sport Conversion, Mopar Air Dam, Good Hood, ARE Cover, Rollpan, Mopar fuel door, LED 3rd Brakelight, Black Headlights, HID Fogs, Powdercoated Black SS Grille, Homebrew Powdercoated bumper grill with smoked turn signals
Interior: Infinity pkg, Slammed1 Bezel, BedRug, SRT Pillar
Performance: Hotchkis F/R SwayBars, Bilsteins, MIT tube, AEM Wideband, Comp 260, 6.1L Pushrods, 6.1L Exhaust Springs, QTP Cutout, Super Chips, NGK 4306s, Taylor Wires, TransGo Shift Kit, AT3030, CalTracs.
Awaiting Install:Thorley Mid's

View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote

weedahoe
 
 Posted: 06-23-2010, 09:38 AM
weedahoe's Avatar
Tricked out Ram
Joined: Jul 2007
Posts: 12,520
City: Albany
State: GA
Status: Offline
Post #3

Yeah i thought about that but wasnt looking to swap out parts to see what I get and that might not resolve it. But then again, with the truck being an 04 and 73k on it, it might be time to replace all of the O2's anyway.
__________________
2004 2wd Dodge Ram QC w/a 5.7 with Royal Purple 5w-20 in the motor, RP Max ATF in the trans, 80-90w in the 4.56 Auburn LSD rolling on American Racing Dale Earnhart "Tank" 24s wrapped in Pirelli 325/45/24s (36" tires)

| Debadged | SRT-10 hood | Custom CAI | Fumoto oil valve | 12" of lift | Power Wire | 9007 Bi-Xenon 6k | 9006 Single Beam 6K | 2nd battery tray (2K CCA total) | Big 3 upgrade w/1ga wire | Altezza clear tails w/LEDs | Clear LED 3rd light | 26gal to 35gal fuel tank swap | Viair 380c air compressor | train horns | Ceramic pads (F&R) | Westin Nerfs | Chrome door/tailgate handles | Custom switch panel | Custom center console | B&M QuickSilver floor shifer | Xbox 360 | Audiobahn A8000V (1600w sub amp) | Audiobahn 2002V (400w mid/high amp) | 2 12" Kicker DVC CVRs in a FoxBox | 4 Kicker DS650s (front & rears) | 2 Kicker KS350s (dash) | 2 8" LCD screens in the sunvisors | 2 6" LCD screens in the headrest | Clifford 50.7x alarm | 20/15% tint | Diablo Trinity - custom and 93 tuned | Mopar 6.1 ignition conversion | Start ignition push button | KRC 210 cam | 6.1 springs & pushrods | 6.1 half covers | 180* T-stat | Taurus E-fan | Pacesetter ceramic LTs | dual DMH cutouts | (2) 4x14" round magnaflows | 4x24" tips | X pipe | Jimmy Jammers | Ported (85mm) TB | Innovate LC-1 wideband | Sonnax transmission pressure booster | Mopar slush mats | RBP grill | powder coated calipers | custom rim/grill lights |

Link to my gallery



Next projects:

- Custom center console
- B&M Quicksilver Floor shifter
- Custom CAI
View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote

Passwordiswhat
 
 Posted: 06-23-2010, 09:44 AM
Passwordiswhat's Avatar
Registered User
Joined: Sep 2007
Posts: 1,081
City: Sugar Land
State: TX
Status: Offline
View This User's Gallery
Post #4

Check this out. It's pretty well detailed and it saved me alot of money.

http://www.p0420.com/
View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote

weedahoe
 
 Posted: 06-23-2010, 10:02 AM
weedahoe's Avatar
Tricked out Ram
Joined: Jul 2007
Posts: 12,520
City: Albany
State: GA
Status: Offline
Post #5

THX man, as soon as I get back to my office I will read over it.
__________________
2004 2wd Dodge Ram QC w/a 5.7 with Royal Purple 5w-20 in the motor, RP Max ATF in the trans, 80-90w in the 4.56 Auburn LSD rolling on American Racing Dale Earnhart "Tank" 24s wrapped in Pirelli 325/45/24s (36" tires)

| Debadged | SRT-10 hood | Custom CAI | Fumoto oil valve | 12" of lift | Power Wire | 9007 Bi-Xenon 6k | 9006 Single Beam 6K | 2nd battery tray (2K CCA total) | Big 3 upgrade w/1ga wire | Altezza clear tails w/LEDs | Clear LED 3rd light | 26gal to 35gal fuel tank swap | Viair 380c air compressor | train horns | Ceramic pads (F&R) | Westin Nerfs | Chrome door/tailgate handles | Custom switch panel | Custom center console | B&M QuickSilver floor shifer | Xbox 360 | Audiobahn A8000V (1600w sub amp) | Audiobahn 2002V (400w mid/high amp) | 2 12" Kicker DVC CVRs in a FoxBox | 4 Kicker DS650s (front & rears) | 2 Kicker KS350s (dash) | 2 8" LCD screens in the sunvisors | 2 6" LCD screens in the headrest | Clifford 50.7x alarm | 20/15% tint | Diablo Trinity - custom and 93 tuned | Mopar 6.1 ignition conversion | Start ignition push button | KRC 210 cam | 6.1 springs & pushrods | 6.1 half covers | 180* T-stat | Taurus E-fan | Pacesetter ceramic LTs | dual DMH cutouts | (2) 4x14" round magnaflows | 4x24" tips | X pipe | Jimmy Jammers | Ported (85mm) TB | Innovate LC-1 wideband | Sonnax transmission pressure booster | Mopar slush mats | RBP grill | powder coated calipers | custom rim/grill lights |

Link to my gallery



Next projects:

- Custom center console
- B&M Quicksilver Floor shifter
- Custom CAI
View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote

TheSatinPumpkin
 
 Posted: 06-23-2010, 10:36 AM
TheSatinPumpkin's Avatar
Low N Slow
Joined: Aug 2004
Posts: 4,448
State: AZ
Status: Offline
View This User's Gallery
Post #6

This is when the non fouler method comes into play when you have no cats. You may have already done that though so maybe more steel wool.
__________________

_- under construction -_

View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote

weedahoe
 
 Posted: 06-23-2010, 02:38 PM
weedahoe's Avatar
Tricked out Ram
Joined: Jul 2007
Posts: 12,520
City: Albany
State: GA
Status: Offline
Post #7

I had those CELs disabled through custom tuning.

But are those the codes guys get when they have no non-foulers and are not custom tuned?
__________________
2004 2wd Dodge Ram QC w/a 5.7 with Royal Purple 5w-20 in the motor, RP Max ATF in the trans, 80-90w in the 4.56 Auburn LSD rolling on American Racing Dale Earnhart "Tank" 24s wrapped in Pirelli 325/45/24s (36" tires)

| Debadged | SRT-10 hood | Custom CAI | Fumoto oil valve | 12" of lift | Power Wire | 9007 Bi-Xenon 6k | 9006 Single Beam 6K | 2nd battery tray (2K CCA total) | Big 3 upgrade w/1ga wire | Altezza clear tails w/LEDs | Clear LED 3rd light | 26gal to 35gal fuel tank swap | Viair 380c air compressor | train horns | Ceramic pads (F&R) | Westin Nerfs | Chrome door/tailgate handles | Custom switch panel | Custom center console | B&M QuickSilver floor shifer | Xbox 360 | Audiobahn A8000V (1600w sub amp) | Audiobahn 2002V (400w mid/high amp) | 2 12" Kicker DVC CVRs in a FoxBox | 4 Kicker DS650s (front & rears) | 2 Kicker KS350s (dash) | 2 8" LCD screens in the sunvisors | 2 6" LCD screens in the headrest | Clifford 50.7x alarm | 20/15% tint | Diablo Trinity - custom and 93 tuned | Mopar 6.1 ignition conversion | Start ignition push button | KRC 210 cam | 6.1 springs & pushrods | 6.1 half covers | 180* T-stat | Taurus E-fan | Pacesetter ceramic LTs | dual DMH cutouts | (2) 4x14" round magnaflows | 4x24" tips | X pipe | Jimmy Jammers | Ported (85mm) TB | Innovate LC-1 wideband | Sonnax transmission pressure booster | Mopar slush mats | RBP grill | powder coated calipers | custom rim/grill lights |

Link to my gallery



Next projects:

- Custom center console
- B&M Quicksilver Floor shifter
- Custom CAI
View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote

dmcelhannon
 
 Posted: 06-23-2010, 03:22 PM
dmcelhannon's Avatar
Moderator David Mack
Joined: Apr 2006
Posts: 28,406
City: McAllen
State: TX
Status: Offline
View This User's Gallery
View Member's FaceBook Profile
Post #8

* subscribe *
__________________

If you start a thread, be responsible and post the final outcome.


2002 Ram 1500 SLT 4x4 QC ~ 02 Ram 45RFE to Jeep GC TCM 5-45RFE Upgrade - (Nov.01) 4.7L with 85K/3142hrs, Knolton Thunder Cylinder Heads & HO Cams by Sawcut, 4.56 R&P/DTT, SRT-10 Pod w/Dynojet Wideband Commander, 2-speed manual transfer case, Clifford Security System w/Auto Start/Auto Windows, RB1 CD/DVD/NAV Infinity Sound System w/30GB iPod, Offroad Package, 33" BFG T/A KO, Mopar Rear Wheel Liners, EBC Greenstuff Roadsport Brake Pads, K&N w/Airaid Jr Modular Intake Tube, BBK 70mm Throttle Body, AIR_RAM Jet Stream Scoop, PML Diff Cover, ASP Underdrive Crank Pulley, MSD 1.65 Alt Pulley, V8 Lincoln E-Fan, FK-60 E-Fan Controller w/relay, 180 Jet T-Stat, Flowmaster SI/DO Exhaust, Tire-2-Tire Chrome Tuber Step, Line of Fire LED Light Bar, Sylvania Ultra Silverstars, $1600 Oil Pickup Tube

Texas 1845: We the People of the Republic of Texas, acknowledging,
with gratitude, the grace and beneficence of God.


~ Waiting to fix my Ram! ~ 2-Years 65-Days and Counting! ~


View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote

TheSatinPumpkin
 
 Posted: 06-23-2010, 03:46 PM
TheSatinPumpkin's Avatar
Low N Slow
Joined: Aug 2004
Posts: 4,448
State: AZ
Status: Offline
View This User's Gallery
Post #9

Yeah the non fouler method was mostly due to bypass those two codes for highflows or catlass setups. Dont know if that is your reason though since you had it removed via tuner.

This is from 06 when there was no 02 delete option yet.

http://www.dodgetalk.com/forums/show...ht=fix+foulers
__________________

_- under construction -_

View Public ProfileSend a private message to %1$sSend email to %1$sFind all posts by %1$sAdd %1$s to Your Buddy List Reply Reply With Quote
Closed Thread


Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
P0430 Cat bank 2 code? compressor man 3G Dodge Ram Performance Talk 10 01-17-2010 08:25 PM
Code P0430 with Magnaflow Y WVHemiRam 3G Dodge Ram Performance Talk 27 04-24-2009 08:51 PM
P0430 Catalyst System Efficiency below Limit - Bank No 2. Daytona_Dan Dodge Caravan General Talk 1 12-19-2007 11:29 PM
P0430 - Threw it AGAIN! SiZzOuRcE 3G Dodge Ram Performance Talk 13 01-17-2007 08:27 PM
Threw Code P0430 - What the hell does that mean? SiZzOuRcE 3G Dodge Ram Performance Talk 11 01-13-2007 10:59 AM



All times are GMT -5. The time now is 06:37 AM.





Privacy Statement